Date: 08.03.2001
Component: Latches/locks/linkages > Doors > Latch
Manufacturer: General Motors Corp.
Description:
Vehicle description: minivans equipped with passenger side power sliding doors. the door closes but may not be latched. if this happens, the power sliding door can open while the vehicle is in motion, particularly when the vehicle ascends a hill, makes a turn, or travels over a rough road surface.
Consequencs:
An unrestrained occupant could fall out of the van and be injured.
Notes:
Dealers will install a new un-latch actuator assembly to the power sliding door. this recall has been continued under safety recall 01v-264. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, or oldsmobile at 1-800-442-6537.
Date: 13.12.2001
Component: Seats > Front Assembly > Recliner
Manufacturer: General Motors Corp.
Description:
Vehicle description: certain mini vans built with second row 50/50 split bench seats or captain's chairs, fail to comply with the requirements of fmvss no. 225, "child restraint anchorage systems." the seat latch anchor wire diameter is greater than 6.1 mm.
Consequencs:
If the connector for a latch-type child restraint is not attached correctly to the anchorage points, the restraint will not properly protect a child in the event of a crash.
Notes:
Dealers will inspect the latch anchor wires and repair those with an improper diameter. owner notification began april 10, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, oldsmobile at 1-800-442-6537, or pontiac at 1-800-762-2737.
Date: 01.02.2001
Component: Air Bags > Frontal
Manufacturer: General Motors Corp.
Description:
Vehicle description: passenger, sport utility vehicles and minivans. the passenger air bag inflator modules were built without the correct amount of generant, which produces the gas that fills the air bag. some were built with a double load of generant and some were built without generant.
Consequencs:
In the event of a crash that would trigger a passenger air bag deployment, a double load of generant can cause the inflator module to explode. if the air bag module explodes, metal and plastic debris could cause severe injury to vehicle occupant. a module with no generant would not inflate the air bag, and the occupants could receive more severe injuries.
Notes:
Dealers will replace the passenger air bag module. telephone calls were made to owners on january 29, 2001. follow up owner mailing began on april 17, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, or saturn at 1-800-553-6000.
Date: 08.03.2001
Component: Latches/locks/linkages > Doors > Latch
Manufacturer: General Motors Corp.
Description:
Vehicle description: minivans equipped with passenger side power sliding doors. the door closes but may not be latched. if this happens, the power sliding door can open while the vehicle is in motion, particularly when the vehicle ascends a hill, makes a turn, or travels over a rough road surface.
Consequencs:
An unrestrained occupant could fall out of the van and be injured.
Notes:
Dealers will install a new un-latch actuator assembly to the power sliding door. this recall has been continued under safety recall 01v-264. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, or oldsmobile at 1-800-442-6537.
Date: 07.08.2000
Component: Seat Belts
Manufacturer: General Motors Corp.
Description:
Vehicle description: passenger vehicles, light duty trucks, sport utility vehicles, and mini vans equipped with trw seat belt buckle assemblies. the buckle base of these seat belt assemblies were not properly heat treated and therefore do not pass the load bearing requirement of federal motor vehicle safety standard no. 209, "seat belt assemblies."
Consequencs:
In the event of a vehicle crash, the occupant may not be properly restrained.
Notes:
Dealers will inspect the vehicle's safety belt buckle assembly date codes and, if necessary, will replace any safety belt buckle assembly.
Date: 07.08.2000
Component: Seat Belts
Manufacturer: General Motors Corp.
Description:
Vehicle description: passenger vehicles, light duty trucks, sport utility vehicles, and mini vans equipped with trw seat belt buckle assemblies. the buckle base of these seat belt assemblies were not properly heat treated and therefore do not pass the load bearing requirement of federal motor vehicle safety standard no. 209, "seat belt assemblies."
Consequencs:
In the event of a vehicle crash, the occupant may not be properly restrained.
Notes:
Dealers will inspect the vehicle's safety belt buckle assembly date codes and, if necessary, will replace any safety belt buckle assembly.
Date: 09.12.2002
Component: Air Bags > Frontal
Manufacturer: General Motors Corp.
Description:
On certain passenger, sport utility vehicles and mini vans, some of these vehicles have a passenger air bag that was manufactured without a check valve pin. an air bag without the check valve pin could produce increased pressure at the onset of the air bag deployment and reduced pressure afterward.
Consequencs:
This could increase the severity of injury to a person who was not properly restrained and who was close to the passenger air bag at the time of deployment. it could also reduce the ab8ility of the air bag to protect a restrained front seat passenger.
Notes:
Dealers will inspect and, if necessary, replace the passenger air bag. owner notification began december 16, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, oldsmobile at 1-800-442-6537, or saturn at 1-800-553-6000, prompt #3.
Date: 15.07.2003
Component: Equipment > Other > Owners/service/other Manual
Manufacturer: General Motors Corp.
Description:
Certain minivans, passenger and sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage system." the owner's manual does not explain the meaning of the location symbols for the child restraint lower universal anchorage system.
Consequencs:
This does not meet the requirements of the standard.
Notes:
Owners will be provided with a supplement for their owner's manual. this supplement describes and shows the location symbols for the child restraint anchors that are located in the vehicle and on the child restraint or booster cushion. owner notification began august 18, 2003. owners should contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, pontiac at 1-800-620-7668, or oldsmobile at 1-800-630-6537.
Date: 08.08.2007
Component: Fuel System, Gasoline > Storage
Manufacturer: General Motors Corp.
Description:
On certain vehicles, variations in the manufacturing process or exposure to high ambient temperatures may lead to fracture of the fuel tank inlet check valve (icv).
Consequencs:
A fracture may allow fuel vapors to pass through and allow droplets of fuel to accumulate on the side of the fuel tank. fuel leakage, in the presence of an ignition source, could result in a fire.
Notes:
Dealers will replace the fuel tank. the recall will be mailed in two phases with the first phase beginning on december 4, 2007. the second phase will be mailed on december 13, 2007. owners may contact buick at 1-866-608-8080; chevrolet at 1-800-630-2438; or pontiac at 1-800-620-7668. the vehicle population includes buick rendezvous and pontiac aztek vehicle built in may 2003; chevrolet venture and pontiac montana vehicles built from june through august 2002; and all vehicles registered in nevada, arizona, virgin islands, puerto rico, and hawaii.
